液滴冲击移动液膜的数值研究

doi:10.13675/j.cnki. tjjs. 180545

推进技术 ›› 2019, Vol. 40 ›› Issue (9): 1944-1952.DOI: 10.13675/j.cnki. tjjs. 180545

液滴冲击移动液膜的数值研究

李淼¹,朱卫兵¹

哈尔滨工程大学航天与建筑工程学院

发布日期:2021-08-15
作者简介:李淼，硕士生，研究领域为流体流动与传热。E-mail：18704508984@163.com

Numerical Study of Droplet Impact on Moving Liquid Film

College of Aerospace and Civil Engineering,Harbin Engineering University,Harbin 150001,China

Published:2021-08-15

摘要/Abstract

摘要： 为了研究液滴冲击移动液膜问题，建立了三维不可压缩层流计算模型，基于耦合的水平集-流体体积法对两相界面进行追踪，探讨了液膜速度和厚度、液滴直径和速度对冲击移动液膜过程的影响。研究表明：液膜静止时，冲击结果是对称的，而液膜移动时，冲击结果变为非对称；液膜速度对冠上游生长具有增强效应，而对冠下游具有抑制作用，增加液膜速度冠的上游高度增加、下游高度减小，内径增加；液膜厚度增加，液膜与壁面的粘性损失减小，吸收冲击动能的能力增强，当无量纲液膜厚度小于1时，冠的上、下游高度均随着液膜厚度的增加而增加，否则相反；当无量纲液膜厚度小于0.5时，冠内径随着液膜厚度的增加而增加，否则反之；随液滴直径和速度的增大，冠的高度和内径均增加。

关键词: 移动液膜;耦合的水平集-流体体积法;两相界面;冠

Abstract: To investigate the problem of droplet impact moving liquid film, a three-dimensional incompressible laminar flow model was established. The two-phase interface was tracked based on the coupled Level Set- Volume of Fluid method. The effects of liquid film velocity and thickness, droplet diameter and velocity on the impact on the moving liquid film process were discussed. The results show that when the liquid film is stationary, the impact results are symmetrical. While the liquid film moves, the impact results become asymmetrical. The liquid film velocity has an enhanced effect on the upstream growth of the crown, while it has an inhibitory effect on the downstream of the crown. With the increase of the liquid film moving velocity, the upstream height of the crown increases, the downstream height decreases, and the inner diameter increases. The thickness of the liquid film increases, the viscous loss between the liquid film and the wall surface decreases, and the ability to absorb the impact kinetic energy is enhanced. When the non-dimensional liquid film thickness is less than 1, the crown height increases with the increase of the liquid film thickness, otherwise the opposite is true. When the non-dimensional liquid film thickness is less than 0.5, the crown inner diameter increases with the increase of the liquid film thickness, otherwise the opposite is true. With the increase of droplet diameter and velocity, the height and inner diameter of the crown increase.

Key words: Moving liquid film;Coupled level set-volume of fluid method;Two phase interface;Crown

李淼,朱卫兵. 液滴冲击移动液膜的数值研究[J]. 推进技术, 2019, 40(9): 1944-1952.

LI Miao¹,ZHU Wei-bing¹. Numerical Study of Droplet Impact on Moving Liquid Film[J]. Journal of Propulsion Technology, 2019, 40(9): 1944-1952.

参考文献

[1] 梁刚涛. 液滴撞击液膜的动力学特性研究[D]. 大连：大连理工大学, 2014.
[2] Pan?o M R O， Moreira A L N. Flow Characteristics of Spray Impingement in PFI Injection Systems[J]. Experiments in Fluids， 2005， 39(2): 364-374.
[3] Horacek B， Kiger K T， Kim J. Single Nozzle Spray Cooling Heat Transfer Mechanisms[J]. International Journal of Heat and Mass Transfer， 2005， 48(8): 1425-1438.
[4] 钱磊. 叶轮式通风器不同参数对其性能影响研究[D]. 哈尔滨：哈尔滨工程大学， 2018.
[5] 张小彬. 动压式油气分离器性能的实验与理论研究[D]. 哈尔滨：哈尔滨工程大学， 2018.
[6] Liang H， Guo D. The Film Forming Behavior at High Speeds Under Oil-Air Lubrication[J]. Tribology International， 2015， 91（7）: 6-13.
[7] Thoroddsen S T. The Ejecta Sheet Generated by the Impact of a Drop[J]. J. Fluid Mech， 2002， 451(1): 373-381.
[8] Wal R L V， Berger G M， Mozes S D. Droplets Splashing upon Films of the Same Fluid of Various Depths[J]. Experiments in Fluids， 2006， 40(1): 33-52.
[9] ? ?ikalo ， Tropea C， Gani? E N. Dynamic Wetting Angle of a Spreading Droplet[J]. Experimental Thermal and Fluids Science， 2005， 29(7): 795-802.
[10] 黄虎，洪宁，梁宏，等. 液滴撞击液膜过程的格子Boltzmann方法模拟[J]. 物理学报， 2016， 65(8): 1-12.
[11] Riber M， Frohn A. A Numerical Study on the Mechanism of Splashing[J]. International Journal of Heat and Fluid Flow， 1999， 20(5): 455-461.
[12] Nikolopoulos N， Theodorakakos A， Bergeles G. Three-Dimensional Numerical Investigation of a Droplet Impinging Normally onto a Wall Film[J]. Journal of Computational Physics， 2007， 225(1): 322-341.
[13] Gao X， Li R. Impact of a Single Drop on a Flowing Liquid Film[J]. Physical Review E， 2015， 92(5).
[14] Burzynski D A， Bansmer S E. Droplet Splashing on Thin Moving Films at High Weber Numbers[J]. International Journal of Multiphase Flow， 2018， 101（4）: 202-211.
[15] Cheng M， Jing L. Lattice Boltzmann Simulation of a Drop Impact on a Moving Wall with a Liquid Film[J]. Computers and Mathematics with Application， 2014， 67(2): 307-317.
[16] Liu C， Shen M， Wu J. Investigation of a Single Droplet Impact onto a Liquid Film with Given Horizontal Velocity[J]. European Journal of Mechanics/B Fluids， 2018， 67（9）: 269-279.
[17] Gueyffier D， Li J， Nadim A， et al. Volume of Fluid Interface Tracking with Smoothed Surface Stress Methods for Three-Dimensional Flows[J]. Journal of Computational Physics， 1999， 152(2): 423-456.
[18] Sussman M， Smereka P， Osher S. A Level Set Approach for Computing Solutions to Incompressible Two-Phase Flow[J]. Journal of Computational Physics， 1994， 114(1): 146-159.
[19] Son G. Efficient Implementation of a Coupled Level-Set and Volume-of-Fluid Method for Three-Dimensional Incompressible Two-Phase Flows[J]. Numerical Heat Transfer， 2003， 43(6): 549-565.
[20] 宋云超. 气液两相流动相界面追踪方法及液滴撞击壁面运动机制的研究[D]. 北京：北京交通大学， 2012.
[21] Cossali G E， Marengo M， Coghe A， et al. The Role of Time in Single Drop Splash on Thin Film[J]. Experiments in Fluids， 2004， 36(6): 888-900.
[22] Mukherjee S， Abraham J. Crown Behavior in Drop Impact on Wet Walls[J]. Physics of Fluids， 2007， 19(5).
[23] Krechetnikov R， Homsy G M. Crown Forming Instability Phenomena in the Drop Splash Problem[J]. Journal of Colloid and Interface Science， 2009， 331(2): 555-559.
[24] Kharmiani S F， Fard M P， Niazmand H. Simulation of a Single Droplet Impact onto a Thin Liquid Film Using the Lattice Boltzmann Method[J]. Journal of Molecular Liquids， 2016， 222（7）: 1172-1182.
[25] Lee S H， Hur N， Kang S. A Numerical Analysis of Drop Impact on Liquid Film by Using a Level Set Method[J]. Journal of Mechanical Science and Technology， 2011， 25(10): 2567-2572.

液滴冲击移动液膜的数值研究

Numerical Study of Droplet Impact on Moving Liquid Film

PDF

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价